Login Register Cart 0
Generic placeholder image

Current Nutrition & Food Science

Editor-in-Chief

ISSN (Print): 1573-4013
ISSN (Online): 2212-3881

Back
Journal Home About Journal Editorial Board Journal Insight Current Issue Volumes/Issues
Subscribe
General Research Article

Preparation and Characterisation of Starchy Foods by Plant Polymers from Abelmoscus esculentus Agro Waste and Gracilaria corticata - for Commercial Food Applications

Author(s): Ganesan Archana and Muthusamy Sukumar*

Volume 16, Issue 9, 2020

Page: [1411 - 1420] Pages: 10

DOI: 10.2174/1573401316666200319140530

Price: $65

Abstract

Objective: The surface modification of high temperature processed potato chips by structurally stable carbohydrate polymer from Abelmoscus esculentus and Gracilaria corticata were studied. The 1% A. esculentus carbohydrate polymer surface coated chips had less coating pick up than the chips coated with a combination of polysaccharide 1% A. esculentus + Gracilaria corticata polysaccharide.

Methods: The mucilage polysaccharides were extracted from the A. esculentus and Gracilaria corticate by hot solvent extraction. The mucilage coating solutions were prepared at 1% concentration individually and in combination for coating the potato strips. The proximate analysis and characterisation of edible coated potato chips were investigated.

Results and Discussion: The proximate analysis of carbohydrate polysaccharide coated potato chips showed a reduction in terms of fiber, ash, reducing sugar with a corresponding increase in protein content than control snacks without any coating treatment. The instrumental textural analysis revealed that maximum force required puncturing the surface structure of 1% A. esculentus and 1% A. esculentus + Gracilaria corticata was 16.3-14.04N and 16.95-14.17N which was higher than the force required for puncturing the surface structure of control chips (15.4-13.3N). The instrumental color analysis was performed by image analysis technique, and the effect of the color values of the structural polysaccharide on snack surface were expressed as L*a*b* values.

Conclusion: The structural stability of both polysaccharides obtained by fracture force was well in agreement with all of the sensory attributes which showed that they could act as structurally stable polymers that could yield the highest crispiness value for the potato chips with better consumer acceptance.

Keywords: Abelmoscus esculentus, carageenen polysaccharide, color analyser, mechanical strength, sensory analysis, snack food.

« Previous Next »
Graphical Abstract

[1]
Abson R, Gaddipati SR, Hort J, Mitchell JR, Wolf B. Hill SE. A comparison of the sensory and rheological properties of molecular and particulate forms of xanthan gum. Food Hydrocoll 2014; 35(100): 85-90.
[http://dx.doi.org/10.1016/j.foodhyd.2013.04.018] [PMID: 24591753]
[2]
Akbar J, Iqbal MS, Massey S, Masih R. Kinetics and mechanism of thermal degradation of pentose- and hexose-based carbohydrate polymers. Carbohydr Polym 2012; 90(3): 1386-93.
[http://dx.doi.org/10.1016/j.carbpol.2012.07.008] [PMID: 22939355]
[3]
Archana G, Sabina K, Babuskin S, Radhakrishnan K, Mohammed A Fayidh, et al. Preparation and characterization of mucilage polysaccharide for biomedical applications. Carbohydrate Polymers 2013; vol. 98: 89-94..
[4]
Ballesteros LF, Teixeira JA, Mussatto SI. Extraction of polysaccharides by autohydrolysis of spent coffee grounds and evaluation of their antioxidant activity. Carbohydr Polym 2017; 157: 258-66.
[http://dx.doi.org/10.1016/j.carbpol.2016.09.054] [PMID: 27987926]
[5]
Cerqueira MA, Lima AM, Souza BW, Teixeira JA, Moreira RA, Vicente AA. Functional polysaccharides as edible coatings for cheese. J Agric Food Chem 2009; 57(4): 1456-62.
[http://dx.doi.org/10.1021/jf802726d] [PMID: 19170503]
[6]
Coelho E, Rocha MAM, Saraiva JA, Coimbra MA. Microwave superheated water and dilute alkali extraction of brewers’ spent grain arabinoxylans and arabinoxylo-oligosaccharides. Carbohydr Polym 2014; 99: 415-22.
[http://dx.doi.org/10.1016/j.carbpol.2013.09.003] [PMID: 24274525]
[7]
FAO. Gum arabic [published in FAO Food and Nutrition Paper 49, 1990] Compendium of Food Additive Specifications FAO Food and Nutrition Paper 52 (Joint FAO/WHO Expert Committee on Food Additives Combined Specifications from 1st through the 37th Meetings, 1956-1990). Rome: Food and Agriculture Organization. 1992; pp. 735-7..
[8]
Farres IF, Norton IT. Formation kinetics and rheology of alginate fluid gels produced by in-situ calcium release. Food Hydrocoll 2014; 40: 76-84.
[http://dx.doi.org/10.1016/j.foodhyd.2014.02.005]
[9]
Garmakhany AD, Mizaei HO, Maghsoudlou Y, Kashaninejad M, Jafari SM. Influence of partial drying on oil uptake and quality attributes of french fries. J Agric Sci Technol 2010; 4: 41-6.
[10]
Garmakhany AD, Mirzaei HO, Maghsudlo Y, Kashaninejad M, Jafari SM. Production of low fat french-fries with single and multi-layer hydrocolloid coatings. J Food Sci Technol 2014; 51(7): 1334-41.
[http://dx.doi.org/10.1007/s13197-012-0660-9]
[11]
Ghasemlou M, Aliheidari N, Fahmi R, et al. Physical, mechanical and barrier properties of corn starch films incorporated with plant essential oils. Carbohydr Polym 2013; 98(1): 1117-26.
[http://dx.doi.org/10.1016/j.carbpol.2013.07.026] [PMID: 23987453]
[12]
Ghavidel RA. Effect of selected edible coatings to extend shelf-life of fresh-cut apples. Int J Agric Crop Sci 2013; 6: 1171-8.
[13]
Lundqvist J, Jacobs A, Palm M, Zacchi G, Dahlman O, Stalbrand H. Characterization of galactoglucomannan extracted from spruce (Picea abies) by heatfractionation at different conditions. Carbohydr Polym 2003; 51(2): 203-11.
[http://dx.doi.org/10.1016/S0144-8617(02)00111-X]
[14]
Moriana R, Vilaplana F, Karlsson S, Ribes A. Correlation of chemical, structural and thermal properties of natural fibres for their sustainable exploitation. Carbohydr Polym 2014; 112: 422-31.
[http://dx.doi.org/10.1016/j.carbpol.2014.06.009] [PMID: 25129763]
[15]
Myllärinen P, Partanen R, Seppälä J, Forssell P. Effect of glycerol on behaviour of amylose and amylopectin films. Carbohydr Polym 2002; 50(4): 355-61.
[http://dx.doi.org/10.1016/S0144-8617(02)00042-5]
[16]
Norton IT, Cox PW, Spyropoulos F. Acid gelation of low acyl gellan gum relevant to self-structuring in the human stomach. Food Hydrocoll 2011; 25(5): 1105-11.
[http://dx.doi.org/10.1016/j.foodhyd.2010.10.007]
[17]
Passos CP, Coimbra MA. Microwave superheated water extraction of polysaccharides from spent coffee grounds. Carbohydr Polym 2013; 94(1): 626-33.
[http://dx.doi.org/10.1016/j.carbpol.2013.01.088] [PMID: 23544583]
[18]
Passos CP, Moreira ASP, Domingues MRM, Evtuguin DV, Coimbra MA. Sequential microwave superheated water extraction of mannans from spent coffee grounds. Carbohydr Polym 2014; 103(0): 333-8.
[http://dx.doi.org/10.1016/j.carbpol.2013.12.053] [PMID: 24528737]
[19]
Passos CP, Sério A, Kukurová K, Ciesarová Z, Nunes FM, Coimbra MA. Microwave assisted extraction of carbohydrate-rich fractions from spent coffee grounds: formulation of biscuits enriched in dietary fibre. Trends Carbohydr Res 2015; 1: 12-7.
[20]
Paula AM, Conti-Silva AC. Texture profile and correlation between sensory and instrumental analyses on extruded snacks. J Food Eng 2014; 121: 9-14.
[http://dx.doi.org/10.1016/j.jfoodeng.2013.08.007]
[21]
Pedreschi F, Cocio C, Moyano P, Troncoso E. Oil distribution in potato slices during frying. J Food Eng 2008; 87: 200-12.
[http://dx.doi.org/10.1016/j.jfoodeng.2007.11.031]
[22]
Peryam DR, Pilgrim FJ. Hedonic scale method of measuring food preference. Food Technol 1957; 11: 9-14.
[23]
Edmister JA, Vickers ZM. Acoustical measures of crispness in foods. Journal of texture Stud 1985; 46: 153-67.
[http://dx.doi.org/10.1016/j.compscitech.2010.11.023]
[24]
Rosa IMD, Kenny JM, Maniruzzaman M, et al. Effect of chemical treatments on the mechanical and thermal behavior of Abelmoscus esculentus fibers. Compos Sci Technol 2011; 71: 246-54.
[http://dx.doi.org/10.1016/j.compscitech.2010.11.023]
[25]
Simões J, Maricato E, Nunes FM, Domingues MR, Coimbra MA. Thermal stability of spent coffee ground polysaccharides: galactomannans and arabinogalactans. Carbohydr Polym 2014; 101(1): 256-64.
[http://dx.doi.org/10.1016/j.carbpol.2013.09.042] [PMID: 24299772]
[26]
Simões J, Nunes FM, Domingues MDM, Coimbra MA. Structural features of partially acetylated coffee galactomannans presenting immunostimulatory activity. Carbohydr Polym 2010; 79(2): 397-402.
[http://dx.doi.org/10.1016/j.carbpol.2009.08.020]
[27]
Sothornvit R, Pitak N. Oxygen permeability and mechanical properties of banana films. Food Res Int 2007; 40: 365-70.
[http://dx.doi.org/10.1016/j.foodres.2006.10.010]
[28]
Sothornvit R, Rodsamran P. Effect of a mango film on quality of whole and minimally processed mangoes. Postharvest Biol Technol 2008; 47: 407-15.
[http://dx.doi.org/10.1016/j.postharvbio.2007.08.005]
[29]
Distantina S, Wiratni M. Gracilaria corticata properties extracted from Eucheuma cottonii, Indonesia. Int J Chem Mol Engin 2011; 5: 487-91.
[30]
Versino F, Lopez OV, Garcia MA, Zaritzky NE. Starch-based films and food coatings: an overview. Starke 2016; 68(11-12): 1026-37.
[http://dx.doi.org/10.1002/star.201600095]
[31]
Vilaplana F, Hasjim J, Gilbert RG. Amylose content in starches: toward optimal definition and validating experimental methods. Carbohydr Polym 2012; 88(1): 103-11.
[http://dx.doi.org/10.1016/j.carbpol.2011.11.072]
[32]
Vilaplana F, Meng D, Hasjim J, Gilbert RG. Two-dimensional macromolecular distributions reveal detailed architectural features in high-amylose starches. Carbohydr Polym 2014; 113: 539-51.
[http://dx.doi.org/10.1016/j.carbpol.2014.07.050] [PMID: 25256517]
[33]
Wu D, Sun D-W. Colour measurements by computer vision for food quality control: a review. Trends Food Sci Technol 2013; 29(1): 5-20.
[http://dx.doi.org/10.1016/j.tifs.2012.08.004]
[34]
Yuan Y, Xu X, Jing C, Zou P, Zhang C, Li Y. Microwave assisted hydrothermal extraction of polysaccharides from Ulva prolifera: functional properties and bioactivities. Carbohydr Polym 2018; 181: 902-10.
[http://dx.doi.org/10.1016/j.carbpol.2017.11.061] [PMID: 29254052]
[35]
Zhao J, Zhang W, Zhang X, Zhang X, Lu C, Deng Y. Extraction of cellulose nanofibrils from dry softwood pulp using high shear homogenization. Carbohydr Polym 2013; 97(2): 695-702.
[http://dx.doi.org/10.1016/j.carbpol.2013.05.050]

Rights & Permissions Print Cite
Article Metrics
16
2
© 2024 Bentham Science Publishers | Privacy Policy